The tornado-proof roof

On Tuesday 3rd May 2011, the Auckland suburb of Albany experienced 'an extreme weather event'. A large tornado touched down at 3.15pm and slammed through a shopping mall before moving south leaving a 5km trail of destruction.

Weather Watch's chief analyst said that the speed of the winds in the tornado would have been between 160kmh and 200 kmh. The tornado claimed one life and seriously damaged close to 30 homes.

One of the houses directly in the tornado’s path was a 12-year-old home belonging to Sharon and Mike Tomoana. Sharon recounts the experience:

"Mike was at home and watched the twister coming towards our house. He said the noise was like the engine of a Jumbo jet – and he should know, he’s an Air New Zealand pilot. As it got closer, he could see sheets of iron and concrete roof tiles whirling around. When he realised that it was headed directly for our house, he ran into the kitchen, lay down on the tiles and covered his head."

Concrete tiles became missiles

An aerial view of the Tomoana’s neighbourhood reveals that several homes suffered extensive roof damage. However the Tomoana’s roof – clad in Gerard Corona Greenstone pressed-steel tiles - remained intact.

 

"Our roof was the only one that stayed down and intact. The only damage we suffered was a slice to one metal tile, caused by a flying concrete tile from the neighbour’s roof. All of the homes around us have concrete tile roofs, and the tiles are fixed with just one nail. In strong winds, the front of the tile lifts and the tile flies off, becoming a lethal missile. They weigh about 3kg each."

Roof failures resulted in extensive water damage

Strong winds were only part of the problem that day. Three hours of torrential rain followed the tornado, drenching the ceiling cavities of homes that had lost their concrete tile roofs.

"Our elderly neighbours lost their concrete tile roof and the rain poured in, soaking their ceiling insulation. The ceiling sagged and you could poke your finger through the gib board. These people are in their 70s and they had to cope with wet ceiling, wet bedrooms and wet carpet. And or course their electricity had to be turned off, because of the risk of electrocution."

Gerard support arrives without delay

Although the Tomoana’s roof suffered nothing more than a slice to one tile, Gerard were at the house before Sharon even thought about calling them.

"We were quite gobsmacked. Mike had just come off the roof and Richard Field, the Gerard Roofs guy, pulls up in the driveway. He said ‘I put your roof on 12 years ago and just want to check that you’re OK’. Mike told him about the little bit of damage and Richard said he’d be back after lunch with the right size piece. Not only did he arrive back with the new tile, he helped Mike to install it so that we wouldn’t get any water in the ceiling cavity."

Gerard gets the nod for beach house

Sharon and Mike hadn’t given their roof much thought before the tornado struck, although Sharon’s brother – a builder – had said to them that they had a ‘hurricane-proof roof’ when they bought the home 12 years ago.

"Mike and I are very grateful to have a Gerard Roof. We bought this house brand new from the builder, and at the time we simply thought it was a good-looking roof. We didn’t realise the durability and quality of our roof until Tuesday’s tornado. We have land in Rarotonga and will be building a beach house on it soon. It will definitely have a Gerard roof. I’ve seen a couple of storms in Raro – having a hurricane-proof roof will be really important there."

Retired farmers choose Gerard
Retired farmers John and Beverly Lundy built their rural retreat with four children and ten grandchildren in mind. The original design of their extended-family-friendly Waikato home called for asphalt shingles but Gerard became the roof of choice in this windy spot in the Waikato.
Read full story
Chimney Sweep Inspires Cottage Makeover
Dave and Ruth had all the reasons in the world to replace their old concrete tile roof. The roof was bowing noticeably from the weight, they had cracks in the ceiling and serious leaks by the bucketful. But it was a comment from their chimney sweep that finally tipped the scales.
Read full story
Gerard Big Hit on Grand Designs TV
A spectacular roofline on a Balinese-inspired pole home generated huge interest after it featured on Australia's top-rating Grand Designs TV show. Seen by an estimated 1.8 million viewers, the hour-long episode followed the construction of a pavilion style "treehouse" with a Gerard Corona roof at Trinity Beach near Cairns in North Queensland.
Read full story

Subscribe to Gerard updates

Just fill in your details below and we’ll add you to our mailing list for relevant and useful information and updates. We promise not to pass on your details to anyone else and you can unsubscribe any time you like.